Class II U.S. Food and Drug Administration

Tornier Perform Reversed Perip Screw 5.0MMX18MM NON Sterile recall: A specific lot of screws is incorrectly labeled. Screws are labeled

Recall published 9 months ago

A specific lot of screws is incorrectly labeled. Screws are labeled as 5.0mmx18mm but actual screws are 5.00mmx14mm. If mismatch is detected during surgery, the issue may cause a minor delay in surgery. If not detected and incorrect screw is used, issue may increase risk of earlier mechanical failure, loosening, and need for revision surgery.

The hazard: Sterility or particulate concern

The concern here is contamination of a product that bypasses the body’s normal defences, which is why the threshold for recalling it is low.

What the notice says: A specific lot of screws is incorrectly labeled. Screws are labeled as 5.0mmx18mm but actual screws are 5.00mmx14mm. If mismatch is detected during surgery, the issue may cause a minor delay in surgery. If not detected and incorrect screw is used, issue may increase risk of earlier mechanical failure, loosening, and need for revision surgery.

Why it matters: The product was made or packaged in conditions that cannot assure sterility, or visible particles were found in it. For anything injected, infused or used in the eye, that is a direct route for contamination into the body.

Symptoms and when to call a doctor

Watch for fever, chills, pain, redness, swelling or discharge at an injection site, and for a red, painful or suddenly blurred eye after using an eye product. Any of these needs same-day medical attention. Do not wait to see whether it settles, and tell the clinician which product and lot you used so it can be reported against the recall.

This page is general information, not medical advice. If you feel unwell, a clinician who can see you is the only person able to judge your case.

Recall details

Recall number
Z-1237-2026
Published
February 11, 2026
Risk level
Class II
Status
Ongoing
Issued by
U.S. Food and Drug Administration
Brand
Tornier, Inc
Product type
Medical devices
Units affected
427
Distribution
Nationwide
Made in
United States
Lot / code info
Lot AZ4824290

Products covered by this recall

TORNIER PERFORM REVERSED PERIP SCREW 5.0MMX18MM NON STERILE, catalog number DWJ318

Check your product

The notice names 1 code you can read straight off the package. Type the one printed on yours and the list below narrows to it.

Lot or batch code

Usually ink-stamped near the seam, the cap or the bottom of the pack.

  • AZ4824290 — 427

Codes are lifted verbatim from the FDA — Device enforcement notice. A code that is missing here may still be covered — the official notice is the complete list.

What to do about Sterility

Tornier, Inc — The concern here is contamination of a product that bypasses the body’s normal defences, which is why the threshold for recalling it is low.

  1. Stop using the affected lot and check the lot number on your own carton or vial against the codes listed above.
  2. Report any infection or reaction you think the product caused to FDA MedWatch.
  3. Do not use a vial or syringe with visible particles, cloudiness or discolouration, whether or not it is on the recall list.
  4. Call your prescriber or pharmacy today about a replacement from an unaffected lot — do not simply skip doses of a medicine you depend on.

Getting a replacement supply

Do not let a refund question interrupt your treatment. Deal with the supply first and the money second.

  • Call the pharmacy before you run low. They can see which lot they dispensed to you and will usually swap it the same day.
  • Insurers do not normally count a recall replacement against a refill limit. If one is refused, ask the pharmacist to call it through as a recall override.
  • Over-the-counter products are refunded at the till like any other purchase; the recall notice on your phone is enough to explain the return.
  • If the manufacturer runs a direct reimbursement form, it will be linked from the official notice on this page.

Company contact: Tornier, Inc — 10801 Nesbitt Ave S, Bloomington, MN, 55437-3109

The official notice

This page summarises a notice published by U.S. Food and Drug Administration. The agency notice is the authoritative version — read it before you act, and treat it as the final word if anything here looks different.

Open the FDA — Device enforcement record U.S. Food and Drug Administration recalls

Questions people ask about this recall

Why was Tornier, Inc medical devices recalled?

A specific lot of screws is incorrectly labeled. Screws are labeled as 5.0mmx18mm but actual screws are 5.00mmx14mm. If mismatch is detected during surgery, the issue may cause a minor delay in surgery. If not detected and incorrect screw is used, issue may increase risk of earlier mechanical failure, loosening, and need for revision surgery. A specific lot of screws is incorrectly labeled. Screws are labeled as 5.0mmx18mm but actual screws are 5.00mmx14mm. If mismatch is detected during surgery, the issue may cause a minor delay in surgery. If not detected and incorrect screw is used, issue…

How do I know if I have the recalled product?

Match the codes printed on your package against the notice: lot code AZ4824290 — 427. If the code on your package is not on that list, your unit is outside the recall.

What should I do with it right now?

Stop using the affected lot and check the lot number on your own carton or vial against the codes listed above.

Can I get my money back?

Call the pharmacy before you run low. They can see which lot they dispensed to you and will usually swap it the same day.

Where was the recalled product sold?

It was distributed nationwide.

Related recalls