• September 18, 2025Fuel system

  Replacement Fuel Tank May Leak During a Rollover Crash

  NHTSA campaign 25V-619 · 12 vehicles potentially affected · Fuel system, diesel

  The defect: General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover crash.

  The risk: A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.

  The remedy: Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252512770. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 18, 2025.

• April 24, 2025Engine and cooling

  Engine Failure

  NHTSA campaign 25V-274 · 597,571 vehicles potentially affected · Engine and engine cooling

  The defect: General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.

  The risk: Engine failure increases the risk of a crash.

  The remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.

• September 12, 2024Brakes

  Inoperative Low Brake Fluid Warning

  NHTSA campaign 24V-674 · 449,671 vehicles potentially affected · Service brakes, hydraulic

  The defect: General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."

  The risk: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.

  The remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.

• September 20, 2023Suspension

  Improperly Heat-Treated Suspension Bolts

  NHTSA campaign 23V-642 · 189 vehicles potentially affected · Suspension

  The defect: General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.

  The risk: A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.

  The remedy: Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.

• December 8, 2022Lighting

  Running Lights May Not Deactivate/FMVSS 108

  NHTSA campaign 22V-903 · 740,108 vehicles potentially affected · Exterior lighting

  The defect: General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

  The risk: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.

  The remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.

Check by VIN

A campaign rarely covers every Tahoe built in 2023. Enter your 17-character VIN to find the recall campaigns filed for your make, model and model year. The VIN is on the driver’s side of the dashboard (visible through the windshield), on the door-jamb label, and on your registration and insurance documents.

Vehicle identification number Find my recalls

Is a recall still open on your vehicle? Only NHTSA’s official VIN check can say whether a campaign applies to your exact vehicle and whether the repair has already been done.

Copy VIN and open NHTSA.gov

Your VIN is decoded with NHTSA’s public vPIC service to identify the make, model and year. It is not stored and is not added to any page address.

Other Chevrolet Tahoe model years

• 2025 1
• 2022 4
• 2021 16
• 2020 3
• 2019 2
• 2018 3
• 2017 4
• 2016 8
• 2015 14
• 2014 3
• 2013 4
• 2012 3
• 2011 5
• 2010 3
• 2009 5
• 2008 4
• 2007 4
• 2006 3
• 2005 5
• 2004 2
• 2003 4
• 2002 3
• 2001 5
• 2000 6
• 1999 1
• 1998 2

Common questions

Does the 2023 Chevrolet Tahoe have any recalls?

Yes. NHTSA lists 5 campaigns for the 2023 Chevrolet Tahoe: 25V-619 (Replacement Fuel Tank May Leak During a Rollover Crash); 25V-274 (Engine Failure); 24V-674 (Inoperative Low Brake Fluid Warning); 23V-642 (Improperly Heat-Treated Suspension Bolts); and 1 more.

How do I know if my 2023 Chevrolet Tahoe has an open recall?

Enter your VIN in NHTSA’s recall lookup. Most campaigns cover only part of a model year’s production, and the lookup also shows whether the repair has already been done on your vehicle.

Will the dealer charge to fix the 2023 Chevrolet Tahoe?

No. Safety recall repairs are done free of charge by Chevrolet dealers. Quote the NHTSA campaign number when you book.