• August 3, 2006Engine and cooling

  Fuel rail damper retainer clip/workhorse

  NHTSA campaign 06V-289 · 38,439 vehicles potentially affected · Engine and engine cooling

  The defect: On certain trucks equipped with an 8.1l v8 (rpo l8-VIN g) engine have a condition in which the engine fuel rail pulse damper retainer clip may fracture resulting in inadequate retention of the damper.

  The risk: If the damper comes loose, a fuel leak may result. Fuel leakage, in the presence of an ignition source, could result in a fire.

  The remedy: Dealers will replace the engine fuel rail pulse damper retainer clip free of charge. The recall began on august 31, 2006. Owners may contact chevrolet at 1-800-630-2438 and GMC trucks at 1-866-996-9463.

• October 5, 2005Steering

  Power steering hose

  NHTSA campaign 05V-455 · 123,592 vehicles potentially affected · Steering

  The defect: Certain passenger vehicles may have been built with a power steering hose that is not to specification. Under extreme steering maneuvers, such as turning the steering wheel fully to the left or right while braking, the hose may fracture and leak fluid.

  The risk: If this were to occur, power steering assist would be lost and increased steering effort would be required. On vehicles equipped with hydro-boost power brakes, it could also result in loss of power brake assist and increased braking effort would be required. If the power steering fluid spray were to spray onto hot engine parts, an engine compartment fire could occur.

  The remedy: Dealers will inspect the power steering hose(s) for two suspect date codes and replace them if required. The recall will begin on october 14, 2005. Owners may contact chevrolet at 1-800-630-2438, GMC at 1-866-996-9463, buick at 1-866-608-8080, cadillac at 1-866-982-2339, isuzu at 1-800-255-6727, or hummer at 1-800-732-5493.

• April 22, 2005Seat belts

  Seat belt routing

  NHTSA campaign 05V-163 · 1,359,824 vehicles potentially affected · Seat belts

  The defect: On certain crew cab pickup trucks and sport utility vehicles, the 2nd row center occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants, especially smaller occupants, seated in this position. Appropriate use of a child seat or booster seat, as recommended for small children, does improve the fit condition for this user group. In addition to instructions on proper infant and young child restraint (with child seats or boosters), special verbiage for restraining older child is included in the owner's manual. Also, the suggested seat belt fit/routing for adults, irrespective of seating position, is described in the…

  The risk: A lap portion of the seat belt routing that is not low and snug on the hips can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury.

  The remedy: Dealers will cut open the guide loop, remove a portion of the loop, and then the remaining two sides should be folded over and secured with a retainer free of charge. The recall began on july 21, 2005. Owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, GMC at 1-866-996-9463, or hummer at 1-800-732-5493.

• April 22, 2005Parking brake

  Parking brake system

  NHTSA campaign 05V-161 · 90,242 vehicles potentially affected · Parking brake

  The defect: On certain pickup trucks equipped with manual transmissions and built with either pbr parking brake systems or trw parking brake systems, the parking brake friction linings may wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.

  The risk: If the parking brake does not hold, unintended vehicle movement could occur, which could result in a crash.

  The remedy: Dealers will install a low-force spring clip retainer for vehicles equipped with a pbr parking brake system. On vehicles equipped with the trw parking brake system, dealers will install a redesigned parking brake cable assembly. The recall began on july 29, 2005. Owners may contact chevrolet at 1-800-630-2438 or GMC at 1-866-996-9463.

• February 14, 2005Power train

  Shift lever position indicator illumination

  NHTSA campaign 05V-055 · 7,194 vehicles potentially affected · Power train

  The defect: Certain sport utility vehicles equipped with an automatic transmission, fail to comply with the requirements of federal motor vehicle safety standard no. 102, "transmission shift lever sequence, starter interlock and transmission braking effect." under certain vehicle starting conditions, the shift lever position indicator located in the instrument panel cluster may not illuminate. If the shift lever position indicator does not illuminate, the driver may not know which gear the vehicle is in.

  The risk: The vehicle may move in an unintended direction resulting in possible injury to others outside of the vehicle.

  The remedy: Dealers will reprogram the instrument panel cluster free of charge. The recall began on february 14, 2005. Owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, and GMC at 1-866-996-9463.

• February 8, 2005Brakes

  Hydro-boost/hydraulic brake/bosch

  NHTSA campaign 05V-043 · 77,411 vehicles potentially affected · Service brakes, hydraulic

  The defect: Certain trucks, sport utility vehicles, and vans equipped with bosch hydro-boost brake assemblies, the hydraulic brake booster pressure accumulator may crack and separate from the hydro-boost assembly during normal operating conditions.

  The risk: If a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. The presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. The loss of fluid would cause increased steering and braking effort and a crash may occur without prior warning.

  The remedy: Dealers will test the hydro-boost assembly for functional operation of the two-function valve. If the hydro-boost assembly fails the test, dealers will replace the assembly free of charge. The recall began on march 23, 2005. Owners may contact chevrolet at 1-800-630-2438, GMC trucks at 1-866-996-9463 and hummer at 1-800-732-5493.

• January 21, 2005Steering

  Steering shaft gear fracture

  NHTSA campaign 05V-018 · 3,344 vehicles potentially affected · Steering

  The defect: On certain trucks, the bolt that attaches the intermediate steering shaft to the steering gear may not meet specification. The bolt may fracture resulting in the loss of steering.

  The risk: If this happens while the vehicle is moving, a crash could occur without prior warning.

  The remedy: Dealers will replace the intermediate steering shaft bolt free of charge. The recall began on january 24, 2005. Owners may contact GMC at 1-866-996-9463 and chevrolet at 1-800-630-2438.

• August 2, 2004Fuel system

  GM/fuel rail

  NHTSA campaign 04V-376 · 1,103 vehicles potentially affected · Fuel system, gasoline

  The defect: On certain sport utility vehicles and pickup trucks equipped with 5.3l (rpo l59) v8 engines, the engine fuel rail crossover tube retainer screws were not manufactured to specifications and may break.

  The risk: If the tube retainer screw breaks, fuel could leak from the fuel rail crossover joint, the engine may stall and, if an ignition source were present, an engine compartment fire could occur.

  The remedy: Dealers will inspect the fuel rail crossover tube and, if necessary, replace the retainer screws. Owners were notified by telephone on july 30, 2004, with a followup owner letter began august 5, 2004. Owners should contact chevrolet at 1-800-630-2438 or GMC at 1-866-996-9463. Note: the GM bulletin lists the tahoe and yukon models because canadian vehicles are included in the bulletin. No u.s. Tahoe or yukon vehicles are included in the u.s. Campaign.

Check by VIN

A campaign rarely covers every Silverado built in 2005. Enter your 17-character VIN to find the recall campaigns filed for your make, model and model year. The VIN is on the driver’s side of the dashboard (visible through the windshield), on the door-jamb label, and on your registration and insurance documents.

Vehicle identification number Find my recalls

Is a recall still open on your vehicle? Only NHTSA’s official VIN check can say whether a campaign applies to your exact vehicle and whether the repair has already been done.

Copy VIN and open NHTSA.gov

Your VIN is decoded with NHTSA’s public vPIC service to identify the make, model and year. It is not stored and is not added to any page address.

Other Chevrolet Silverado model years

• 2016 2
• 2015 7
• 2014 13
• 2013 3
• 2012 2
• 2011 2
• 2008 1
• 2007 1
• 2006 4
• 2004 8
• 2003 6
• 2002 4
• 2001 4
• 2000 8
• 1999 5

Common questions

Does the 2005 Chevrolet Silverado have any recalls?

Yes. NHTSA lists 8 campaigns for the 2005 Chevrolet Silverado: 06V-289 (Fuel rail damper retainer clip/workhorse); 05V-455 (Power steering hose); 05V-163 (Seat belt routing); 05V-161 (Parking brake system); and 4 more.

How do I know if my 2005 Chevrolet Silverado has an open recall?

Enter your VIN in NHTSA’s recall lookup. Most campaigns cover only part of a model year’s production, and the lookup also shows whether the repair has already been done on your vehicle.

Will the dealer charge to fix the 2005 Chevrolet Silverado?

No. Safety recall repairs are done free of charge by Chevrolet dealers. Quote the NHTSA campaign number when you book.