• October 26, 2015Engine and cooling

  Engine Oil Dripping On Manifold may Cause Fire

  NHTSA campaign 15V-701 · 1,003,556 vehicles potentially affected · Engine and engine cooling

  The defect: General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

  The risk: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

  The remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engine’s front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer…

• April 6, 2015Engine and cooling

  Engine Oil Dripping On Manifold may Cause Fire

  NHTSA campaign 15V-201 · 330,742 vehicles potentially affected · Engine and engine cooling

  The defect: General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.

  The risk: The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.

  The remedy: GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at 1-800-762-2737 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14574.

• July 3, 2014Electrical system

  Ignition Switch may Turn Off

  NHTSA campaign 14V-400 · 5,877,718 vehicles potentially affected · Electrical system

  The defect: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the…

  The risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

  The remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

• June 23, 2004Brakes

  GM/front brake caliper bolt torque

  NHTSA campaign 04V-287 · 47,991 vehicles potentially affected · Service brakes, hydraulic

  The defect: Certain passenger vehicles were produced with lower than specified torque on both front brake caliper to steering knuckle attachment bolts. With improper torque, the clamp load at the joint may not be adequate to prevent movement between the caliper bracket and knuckle.

  The risk: Depending on whether one or both bolts backs out or fractures, the result can be locking of the affected wheel during braking and an abrupt steering input in the direction of the locked wheel, reduced braking and noise from the affected wheel, or severing of a brake hose, increased brake pedal travel, and reduced steering control. Reduced braking or steering control could cause a crash.

  The remedy: Dealers are to tighten both bolts to the specified torque. Owner notification began on june 28, 2004. Owners should contact chevrolet 1-800-630-2438 or pontiac 1-800-620-7668.

Check by VIN

A campaign rarely covers every Impala built in 2004. Enter your 17-character VIN to find the recall campaigns filed for your make, model and model year. The VIN is on the driver’s side of the dashboard (visible through the windshield), on the door-jamb label, and on your registration and insurance documents.

Vehicle identification number Find my recalls

Is a recall still open on your vehicle? Only NHTSA’s official VIN check can say whether a campaign applies to your exact vehicle and whether the repair has already been done.

Copy VIN and open NHTSA.gov

Your VIN is decoded with NHTSA’s public vPIC service to identify the make, model and year. It is not stored and is not added to any page address.

Other Chevrolet Impala model years

• 2019 1
• 2018 1
• 2015 3
• 2014 12
• 2013 1
• 2012 3
• 2011 2
• 2010 4
• 2009 5
• 2008 2
• 2007 2
• 2006 1
• 2005 1
• 2003 5
• 2002 4
• 2001 7
• 2000 7

Common questions

Does the 2004 Chevrolet Impala have any recalls?

Yes. NHTSA lists 4 campaigns for the 2004 Chevrolet Impala: 15V-701 (Engine Oil Dripping On Manifold may Cause Fire); 15V-201 (Engine Oil Dripping On Manifold may Cause Fire); 14V-400 (Ignition Switch may Turn Off); 04V-287 (GM/front brake caliper bolt torque).

How do I know if my 2004 Chevrolet Impala has an open recall?

Enter your VIN in NHTSA’s recall lookup. Most campaigns cover only part of a model year’s production, and the lookup also shows whether the repair has already been done on your vehicle.

Will the dealer charge to fix the 2004 Chevrolet Impala?

No. Safety recall repairs are done free of charge by Chevrolet dealers. Quote the NHTSA campaign number when you book.